验货用缺陷英文词语

English中文abrasions撞壞

adequate適當

adhesive粘合

askew歪

axle車軸

bad smell臭味

base底下

bean bag豆袋

bent彎曲

blind hole盲孔

bottom底

broken皺/腐

bubble氣泡

burn mark燒焦紋

burr披鋒(金屬)

cable tire broken綁帶斷

came　off脫掉

cannot close不能關

cannot free roll不能滾動

cannot free wheel輪不能順轉

cannot hold position不能保持位置cannot move不能移動

cannot open不能開

clamp mark鉗痕

cold mark合金有冷紋

color dispatch不對／不配色

color migration染色

component零配件

crack裂

dead spider/insect死蜘蛛／昆蟲decorating裝飾

deform變形

dent surface表面粗糙

dents缺口／崩口deviation偏差

difficult pull out拉出困難

dirty污漬

dull color啞色

duplicate重複的

durability耐久性

dust塵埃

eccentric中心偏位

egg crate蛋格

elastic橡筋

electro-plating black mark電鍍發黑

epoxy冷凝膠

explode /blow up爆炸

figure形態

flake剝落

flash披鋒(塑膠)

flaws裂紋

foreign paint顏油污漬fragments斷片

frayed毛邊

gap縫隙

gate縫隙

gear loose齒輪鬆

gift box grease彩盒有油脂

gloss光滑

hole not concentric孔偏心

human hair人頭發

insect hole蟲孔

int mal-function其中某一間歇性功能int non-function間歇性無功能integrity完整無缺intermittent(int)-function間歇功能

litho label貼紙

loud 大聲

mal-function其中一功能不良missing/insufficient segment漏或不足顯示missing parts漏配件

mix-color/uneven color flowing混色

mixed spot混點

non-function無功能

oxidation氧化

peeling剝落

pigments顏料

plate電鍍

plating peel off電鍍脫落

plush毛絨布

point角／點

polarity正負极

poor assembly裝配不良

poor chrome plate電鉻不良

poor electro plating電鍍不良

poor flocking搪膠植毛不良

poor function功能不良

poor heat seal熱燙不良poseable手腳能動公仔re-paint補油

rear后面

resists抵抗

rotate/spin轉動

rough粗糙

rubbing摩擦

run走了

rust生銹

scratch刮花

screen網／螢幕screw not tighten螺絲鬆

seal/stick粘合

seam線口

sewing車縫

shaft鐵輪

shape形狀

sharp edge銳邊／利邊sharp point 利角

short circun短電路shrinkage縮水

silk絲

sketch劃形狀

skin皮

slim/thin薄的

slivers裂片

small細小

smear弄髒

soft toy布類玩具soiling沾污

solder焊錫

solvent溶劑stabilize穩定

stitch 編法

strap loose皮帶鬆stress壓力

stuch粘住不能動stuff塞滿

swell膨脹

texture織物結構through hole穿孔

tight緊

torn撕爛

trap攝住／困

tread/wire線

trim打磨／修飾

tumble-sanded滾筒砂磨

un-trim不修飾

uneven不對稱

unsanded未砂磨的

unseal無粘合的

up side down方向側轉

velcro魔術貼

visual可見的

warpage變形 變曲

weld焊接

weld line夾痕

without gloss/dull color無光澤

without punch hole漏打孔

wrinkle皺摺

abrasion mark擦花

air bubble 氣泡(壓線)

arms orlegscan't hold position手或腳不能保持位置bald spot on plush長毛脫落露底

body shell broken身袋爆裂

broken head cause by hair rooting頭爆(車發不良引起) color contamination顏色混點

color deviation顏色偏差

color migration甩毛(經磨擦)

color misalignment不對稱色澤

color mismatch不配色

color unmatch顏色不對contamination mark混色

cut mark削痕

density of rooting spin count of hair頭發密度不合要求dent mark凹痕

dirt mark臟跡

doll is not fixed tightly公仔未綁穩

edge of seam fraying 布邊披口

electro plating abbades電鍍擦花

electro plating rainbow電鍍成五彩色electro plating shadow電鍍陰陽色

fabric fray纖維散口

fabric texture mismatch布料組織不對

fold mark/line摺痕/紋

foreign human hair人類頭髮

foreign liquid外來液體

foreign materials外來材料

gap縫隙

gassy (glue)膠水引至霧氣gear smooth滑牙

glue mark 膠水漬

grease mark機油漬

hair belt come off頭箍脫落

hair poor cutting 頭髮剪裁不良hairtrapped by seam頭髮夾於縫口

hair yarn is not flame retardant冷發不是防火冷high dense stitch車縫太密incorrect color 錯色

inpure plastic塑料不純

jumping stitch跳針

label peel off貼紙翹起

low dent stitch車縫太疏

material fray物料散口materials run物料走紗materials torn物料被撕爛mercury come off甩水銀

metal exposed露金屬

metal eye shell exposed out眼鐵殼外露

metal wire exposed out from plastic tube鐵線露出膠管missing stitch漏車縫

not conform to requirement不符合要求

not enough stuffing入棉不足

oil mark油漬

outfit fade公仔衫褪色

outfit shirinkage公仔衫縮水

outfit unfit公仔衫不合身outfit wet公仔衫濕

over glue膠水過多

over stuffing入棉過多

painting faded out退色

pile trapped by seam長毛夾於縫口poor brushing纖毛不良/梳發不良poor cutting剪裁不良

poor die-cast合金壓練不良poor embroidery刺繡不良

poor hair inter-lock stitching車發鎖針不良poor hair style發形差

poor heat sticking熱點不良

poor hot melting溶含不良

poor hot stamp熱燙/燙金不良

poor hot stamping 燙劃不良

poor lock stitching鎖針不良

poor booted hair車發不良

poor sewing 車縫不良

poor silk-screening絲印不良

poor sketching釘縫形狀不良

poor stitch縫合不良

poor stuffing入棉形狀不良

pucker縫邊皺起

ribbon fray 絲帶散口

rough surface表面不平滑

scratch mark刮花/劃痕

screw burst螺絲披鋒

screw came off螺絲脫落

screw rust螺絲生銹

screw unfasten螺絲未上蓋

seam allowance expose縫合/焊縫外露

seam open縫口爆開

sewing label loosen布標脫落

sewing machinery mark衣車靴痕

stitching hole 針孔

stuffing disproportion入棉比例不對稱

stuffing expose/cotton expose棉料外露

stuffing expose 露棉

the eyes can't move smoothly眨眼不良

thread trapped by seam長線夾於縫口

under glue膠水少

uneven shape形狀不對稱

uneven stuffing入棉不平衡untrimmed thread線未剪

use unmatched swatches in one boll公仔錯用不合適裁片velcro come off/magic tape come off魔術貼甩出

velcro detach魔術貼甩出

velcro position too hight/low魔術貼位置太高/太低water stain mark水痕跡

wrong assembly裝配錯誤

wrong sewing of botton,hook and loop釘錯鈕

yarn run走紗

zipper difficult to open拉鏈難開

blind nail隱頭釘

bolt螺釘

coating off on surface披覆脫落

damaged screw螺牙破損

dog spike鉤頭釘

dowel nail棗核釘

hob nail平頭釘

magnet磁鐵

nail釘子

nut螺絲帽

oval head nail半圓頭釘

oxidized金屬氧化／金屬生銹poor coating披覆不良

poor plating電鍍不良

poor welding焊接不良

screw螺絲/螺絲釘/ socket screw環頭螺絲

spike大釘

spring nail無頭釘

square nail方頭釘

staple口型釘

stub nail斷釘

un-even coating披覆不平

uneven end尾端突出upholstery nail包頭釘

with virdigris生銅綠

wrong coating color披覆顏色不對wrong diameter of steel wire直徑不符

back plate底板

bushings直身襯套

cavity凹模板

cavity retainer plate凹模托板/托板

cold slug well冷膠井

cooling line冷水管

cooling system冷卻系統

core plate击模板degating脫水白dowel pins縫釘ejecting system脫模系統ejector pins頂針ejector plate頂針板ejector retainer plate頂針托板eye bolt 螺絲圈gate水口

guide pins直身導針hot runner熱流道injection pressure排膠壓力jiffy-lock ejector pins固定頂針locating rings中心環main runner主流道mold cavity模腔

muti-cavity mold多穴模nozzle噴嘴regrind翻磨return pins回針runner流道scorch燒膠secondary runner次流道short shot短注shoulder bushings有托襯套single cavity mold單腔模spacer block凳子板special water junctions長喉嘴spring 彈簧stepped ejector pins有托頂針stop pins頂針板限針stripper bolts拉桿螺絲support pillars支柱thermal degradation熱分解

thermocouple熱偶viscosity粘度

water junctions短喉嘴

air compressor空氣壓縮機auger bit螺絲鑽頭ball bearing鋼球軸承belt輪帶bench vice抬式虎鉗broach拉槽機center punch打孔器chuck夾頭circular saw圓鋸circular saw blade圓鋸片cog齒輪compression chuck鬆緊夾頭core drill空心鑽cramp夾

disk saw輪鋸

drill鑽

drill press鑽機drilling machine鑽床driving傳動electric abrader砂輪機electric drill/hammer drill電鑽gimlet手鑽grinder砂光機grinding wheel砂輪jigsaw連線鋸jumper 長鋸

kerf鋸口

lathe車床

lathe tool車刀polisher打光機power meter電表

pulley皮帶盤punching machine二中床

race rotation空轉

radial arm saw萬能機riveting punch鉚釘打孔器roller bearing滾棒軸承rotary drill轉動鑽機rotary vice旋轉虎鉗sander砂磨機

saw blade鋸條

saw dust / soobs鋸屑/鋸末saw tooth鋸齒

saw horse鋸木機screw driver螺絲刀shifting spanner活動扳頭socket wrench套筒扳頭spanner 螺旋扳頭spring collate彈簧夾頭

t-wrench十字扳頭three-jar chuck三夾頭

tool sharper磨快器transformer變壓器tubular saw圓切鋸

two-jar chuck二夾頭

vice老虎鉗washer墊圈abnormal sound/noisy雜音antenna damaged天線爛battery cap came off電池蓋甩出battery coil over heat電池線圈發熱battery contact plate came off電池片甩出battery contact plate expose電池片外露battery contact plate loosen電池片鬆battery contact plate rust電池片生銹

battery polarity label come off電池极性指示標貼甩出battery polarity label up side down電池极性指示標貼倒轉battery spring came off電池彈簧甩出

battery spring expose 電池彈簧击出

battery spring loosen電池彈簧鬆

battery without power電池沒有電

cassette door poor assy卡式機門裝配不良circuit board damage電路板壞/斷路

circuit board loosen電路板鬆/斷路

circuit board non-function電路板無功能

electric leakage漏電

electric toy電動玩具

frequency weak頻率弱

hot melt insufficient熱熔膠不足intermittent(int)-function間歇功能

intermittent non-function間歇無功能

light bule without light燈泡不亮

missing battery cover漏電池蓋

missing protect tape漏保護膠貼

missing screw漏螺絲

nal-function其中某一功能不良

no sound無聲音

non-function無功能

poor contact接觸不良

poor function功能不良

poor soldering焊錫不足

poor switch開關不良

resin mark鬆香漬

short circuit斷電路

small sound小聲音/細聲音

sound too loud大聲音

switch int non-function開關間歇無功能switch non-function開關無功能

switch too loosen摯鬆

switch too tight摯緊

too tight when turning the key摯轉動時太緊

watch belt loosen表帶鬆

wire detach電線甩出

wire expose 電線击出

wire poor welding電線焊接不良without completed display/fade出現不整顯示without display無顯示

abrasion mark from mold模具磨傷

abs/ acrylonitrile-butadience-styrene有毒的一種不碎膠bittleness脆

bs/ buadiene styren bs料

bubble inside plastic原料中有氣泡

bump/scratched mark碰傷/刮傷

ca/ cellulose acetate酸性膠

chipped有缺口

cn/ cellulose nitrate賽璐

color shade different色差

broken/crack破損,斷裂/裂痕damage by mold release脫膠

deformed變形

degraded material水口料

dirty stain雜質污點(外在) ejector mark頂針位

easy broken (too much used material in)易脆裂(次料摻入太多) embedded dirty雜質污點(內在)

eva/ ethylene-vinyl acetate copolymer橡皮膠

excessive flash大披鋒

excessive or unpleasant odour容器內有怪味

flow line/mark夾水紋/痕

foreign matter in外物殘留

gate remnant水口

ggps/ general purpose polystyene普通硬膠

hdpe/ high density polyethylene高密軟膠

hips/ high impact polystyrene高沖擊硬膠

ldpe/ low density polyethylene低密軟膠

impurity spot mixed in material水痕

mms/ methyl methactylate butadtiene 改性有機玻璃

oil mark油污

over cut毛邊修整過多

pa/ polyamide尼龍類

part line夾模線

part line misalignment夾模線離位

pc/ polycartbonate防彈膠

pear skin沙梨皮/(搪膠)

pet/ polyethylene terephthalate聚酯

pf/ phenol-formaldehyde電木粉

plastic remnant膠碎未清/殘餘

plastic residue膠絲碎

plastic toys塑膠玩具

pmma/ polymethyl methacrylate亞加力

pom/ polyoxy-methylene resin賽鋼

poor lamination披膜不良

poor rotocasting搪膠不良

poor sonic weld超聲不良

poor transparency透明度不良

poor trimming毛邊未修齊

poor welding超聲不良/電鍍不良

pp/ polypropylene百析膠/pp

pu/ polyurethane pu

pvc/ polyvinyl chloride resin pvc

rotacast too thin搪膠薄

san/ styrene-acrylonitrile copolymer san料

sharp flash point 射出點尖銳

sharp edge邊緣尖銳

short shot/undershot走料不到/足(射出不足) shot壓練出來

shirink mark/shrin kage縮水

sink mark/dent凹陷痕

si/ silicone硅樹脂

solvent mark溶劑印

sonic weld超聲

stress mark泛白

under cooked plastic 生膠

uneven wall thickness膠件厚度不平均untrimmed at rim毛邊未修untrimmed flash point射出點未修平void穿孔

weld line夾水印

blurred印刷不清楚discoloration顏色不均lacquer accumulation聚漆

over spraying飛油

paint涂油

paint abrades噴油擦花

paint accumulation聚油

painting噴漆

painting scratched off刮甩油

poor printing印刷不良

poor spraying噴油不良

poor tempo/ poor silkprint絲印不良

print印刷

under spraying噴油不足uneven spraying厚薄不均噴油alder赤陽木antiseptic防腐

banding木材扭曲

bad smell有怪味

bark剝披

beech櫸木

bending彎曲度

birch樺木

bisect平分為二broken strap捆扎中有斷裂者burr毛口

chip木屑

closed-pore密閉氣孔coarse grain粗紋

cork軟木

cross grain斜紋

curly grain卷紋

dirt stain beform lacquer上光前粘有污漬distort歪曲/扭曲/變形encased know暗節

even grain均紋

excelsior刨花fiberwood纖維板

fine grain細紋

gnarl木節

grain木紋

hair out須邊突出

hard maple硬楓木hardness硬度

hickory山胡桃木

kiln drying烘乾

knothole節疤/孔

knotty多節

left over殘料

loose strand緊密度不足moisture not meet requirement干燥度不足mottled grain斑紋

musty發霉

noggin piece木筋

peg木釘

plywood夾板

poor lacquer上光不良

poplar白楊木

rotten wood腐木

rubber tree橡膠木

sap gum楓香邊材

sapwood邊材

shape distorted形狀走樣

too many nodes than aproved sample材料節部太多

variation of color on材料雜色太多

wrong size尺寸不對

assortment pack混合裝

bilingual pack兩種語言的包裝(說明書) blister card damage吸塑卡爛

blister card poor die-cut吸塑卡剪裁不良

blister card wet吸塑卡濕水

blister card wrinkle吸塑卡皺

blister card wrong die-cut吸塑卡剪裁錯誤

blister crack吸塑卡裂

blister crushed吸塑卡壓凹

blister damage吸塑爛

blister deform吸塑變形

blister detach吸塑甩開

blister detached from card 吸塑罩不穩/易甩開blister loose off吸塑罩鬆

blister pack吸塑包裝

blister poor heat sealing吸塑不良

blister shrinkage吸塑縮水

blister undershot吸塑走料

blister unseal吸塑不粘

bulk pack散裝

burn mark on blister吸塑燒焦

burn mark on blister card吸塑卡燒焦

butterfly hook蝴蝶孔

butterfly hook damage蝴蝶孔爛

butterfly hook poor die-cut蝴蝶孔剪裁不良

butterfly hook wrinkle蝴蝶孔皺butterfly hook wrong die-cut蝴蝶孔剪裁錯誤cable tie結束帶

carton glue tape loose大箱封箱紙鬆carton mark illegible大箱箱印模糊color box crumple彩盒弄皺

color box crushed彩盒壓爛/壓皺color box deform彩盒變形

color box flap seam open彩盒縫口爆開color box illegible彩盒濛

color box pack彩盒裝

color box wet彩盒濕

color box window sheet dirty彩盒玻璃窗髒污date code illegible日期印濛

dent mark on window box film彩盒膠窗有凹痕display box pack開口彩盒裝euro-slot size wrong蝴蝶洞尺寸不對fold mark on bilster card吸塑卡有折痕foreign matter trapped in blister泡殼中夾有雜物hang tag吊卡

header 頭卡

heat sealed broken熱封口破裂incorrect assortment pack混裝之數目不符incorrect blister爛 j-形勾incorrect blister card皺 j-形卡incorrect color box用錯彩盒incorrect polybag用錯塑膠袋inner carton內箱

insert card內卡

insert damaged內卡爛instruction sheet說明書instruction sheet illegible說明書濛

j-hook sticker j-形勾貼

j-hook j-形勾

j-hook damage j-形勾爛

j-hook poor die-cut j-形勾剪裁不良

label sticking improperly招貼粘貼不良

master carton外箱

missing component漏零配件

missing date code 漏日期印

missing parts漏裝配件

missing warning word on polybag塑膠袋未加警語missing whole pack of accessory漏整包配件

outer over weight外箱超重

poor heat sealing熱封不良

poor heat sealing blister泡殼熱熔不夠緊密poor printing印刷不良

poor print registration套印不良

poor label adhensived標籤粘貼不良polybag damage膠袋爛

polybag material not meet requirement塑膠袋材料不正確polybag not by upside down塑膠袋套入不正確polybag outstep to euro-slot塑膠袋超出蝴蝶洞polybag without punch未加打通氣孔

sealing tape not properly膠紙粘貼不良

shirink wrap收縮包裝

shirink wrap broken 收縮包裝破裂

shirink wrap loose收縮包裝太鬆

soft corrugated carton外箱太簿

solid pack獨立裝

sticker貼紙

story book illegible故事書濛

styrofoam dirty發泡膠污濁

use non-peelable label未使用可重覆使用標貼white mark on window box film彩盒膠窗發白

whole pack整包

window box film damage彩盒膠窗爛

window box film detach彩盒膠窗脫落

window box film poor sealing彩盒膠窗粘貼不良window box film poor transparency彩盒膠窗透明度不良window box film stress彩盒膠窗預白window box pack有膠窗彩盒裝

wire tie鐵線扎帶

wrong assorted數量混裝不正確wrong quantity packed in數量不對

color thread trapped inside有色線被包入

fabric fault布料瑕疵

fabric frayed布料磨破

hole in fabric布有破洞

loose stitches斷線

needle chew line吃線

open seam車縫處繃開skipped stitch車縫跳針untrimmed thread end線頭未修整

black spot 黑點

clay lump under glazed釉有突出物

foreign matter stuck on surface外物附著於表面impurities陶土中有雜質

pin hole針孔

pimple粉刺

poor glazing上釉不良

smeared painting彩繪污點

uneven glazing 上釉不均勻unsmooth surface表面不平滑contamination有污染物

detached parts零件脫落

improper assembly裝配不緊malfunctuion無功能

missing parts零配件短缺

not close properly無法密合

poor assembly裝配不良

poor screening網版印刷不良

rivet damaged鉚釘損壞water leakage漏水wobbled base搖晃不平